Evaluation of Thin Coatings Wear
Institute for Problems in Mechanical Engineering of the RAS;
Y. A. Fadin
Institute of Problems of Mechanical Engineering, Russian Academy of Sciences, St. Petersburg; Head of Laboratory
A. D. Bykova
Institute for Problems in Mechanical Engineering of the RAS;
M. A. Markov
St. Petersburg State Technological Institute (Technical University), Department of Chemical Technology of Silicate Materials;; Post-Graduate Student
A. A. Shepelevskiy
Institute for Problems in Mechanical Engineering of the RAS, Senior Researcher;
Read the full article
Abstract. A new method is proposed for quantifying the wear of solids based on the acoustic emission phenomenon. The advantage of this method over others is that assessment of the amount of wear can be made directly in the friction of solids. The proposed method can be used to evaluate coatings of materials with thicknesses from units to several tens of microns. The performance of the method idea was tested on a titanium nitride coating on a titanium substrate.
Keywords: surface, wear, acoustic emission, Fourier spectrum, relative wear resistance, thin coating
References:
References:
- Moskvitin G.V. Birger E.M., Polyakov A.N., Polyakova G.N. Metalloobrabotka, 2015, no. 2.1(85), pp. 44–49. (in Russ.)
- Trefilova N.V. Modern high technologies, 2014, no. 10, pp. 67–67. (in Russ.)
- Suminov A.V., Epel'fel'd A.V., Lyudin V.B., Krit B.L., Borisov A.M. Mikrodugovoye oksidirovaniye (Teoriya, tekhnika, oborudovaniye) (Microarc Oxidation (Theory, Technique, Equipment)), Moscow, 2005, 368 р. (in Russ.)
- Berlin E.B., Seidman L.A. Polucheniye tonkikh plenok reaktivnym magnetronnym napyleniyem (Production of Thin Films by Reactive Magnetron Sputtering), Moscow, 2014, 260 р. (in Russ.)
- Holmberg K., Matthews A. Coatihgs tribology, Elsevier Science, 1994, 457 p.
- Novak R., Polcar T. Tribology International, 2014, vol. 74, рр. 154–163.
- Fadin Yu.A. Friction and Wear, 2008, no. 1(29), pp. 29–32. (in Russ.)
- Knott J.F. Fundamentals of Fracture Mechanics, Butterworths, 1979.
- Bezenkina O.S. Kinetika iznashivaniya keramik (Ceramics Wear Kinetics), Extended abstract of candidate’s thesis, St. Petersburg, 2013, 17 р. (in Russ.)
